TOSHIBA TLP250(INV) Manual
Contents
1. 578 TLP250 ny FS TOSHIBA TLP250 INV TOSHIBA PHOTOCOUPLER GaAlAs IRED amp PHOTO IC TLP250 INV Unit in mm TRANSISTOR INVERTER INVERTERS FOR AIR CONDITIONER IGBT GATE DRIVE POWER MOS FET GATE DRIVE le 0 25 The TOSHIBA TLP250 INV consists of a GaAlAs light emitting diode and a integrated photodetector i i S 7 62 0 25 This unit is 8 lead DIP TLP250 INV is suitable for gate driving circuit of IGBT or power MOS FET Input Threshold Current lF 5mA MAX Supply Current ICC 11mA MAX Supply Voltage VCC 10 35V 2 54 0 25 Output Current lO 2 0A MAX Switching Time tpLH tpHL 0 5us MAX Isolation Voltage 2500Vrms BEI UL Recugnized UL1577 File No E67349 TOSHIBA 11 10C4 Option D4 Weight 0 54 g VDE Approved DIN VDE0884 06 92 Certificate No 76823 Maximum Operating Insulation Voltage 630Vpx Highest Permissible Over Voltage 4000Vex Note When a VDE0884 approved type is needed Please designate the Option D4 Creepage Distance 6 4mm MIN Clearance 6 4mm MIN TRUTH TABLE PIN CONFIGURATION TOP VIEW 1 N C 3 CATHODE ON ON OFF 4 N C korgen Ee Ee a 6 VO OUTPUT 7 VO 8 VCC SCHEMATIC lcc Vcc Vo Vo o A 0 1uF bypass capacitor must be 5 GND Connected between pin 8 and 5 See Note 5 1 2002 06 27 TOSHIBA TLP250 INV MAXIMUM RATINGS Ta 25 C CHARACTERISTIC SYMBOL RATING UNIT e E HY a E H Peak PW2. 2 5us f lt 15 kHz Output Current PWs1 0us f 15 kHz 1 Peak PWS2 5us f 15 kHz Output Current PW 1 0us f 15 KHz Output Voltage DETECTOR Supply Voltage Lead Soldering Temperature 10s EIET Isolation Voltage AC 1min R H lt 60 Ta 25 C Note 4 2500 Note 1 Pulse width PWs1yus 300pps Note 2 Exporenential Waveform Note 3 Exporenential Waveform lopH 1 0A S 2 5us lop S 1 0A S2 5ys Note 4 Device considerd a two terminal device pins 1 2 3 and 4 shorted together and pins 5 6 7 and 8 shorted together Note 5 A ceramic capacitor 0 1uF should be connected from pin 8 to pin 5 to stabilize the operation of the high gain linear amplifier Failure to provide the bypassing may impair the switching proparty The total lead length between capacitor and coupler should not exceed 1cm RECOMMENDED OPERATING CONDITIONS CHARACTERISTIC SYMBOL UNIT 2 2002 06 27 TOSHIBA TLP250 INV ELECTRICAL CHARACTERISTICS Ta 20 70 C Unless otherwise specified CHARACTERISTIC SYMBOL ae TEST CONDITION UNIT Input Forward Voltage i Mem ee ie 10mA Ta 25 C 10mA Ta 250 mA Ta 25 C Temperature Coefficient of AV ATa l 10 mA mV C Forward Voltage ee Input Reverse Current Input Reverse Current Current Va 5V Ta 25 C O Va 5V Ta 25 C V Ta 25 C Son Output Current Ex Output Voltage Veca 15V VEE1 15V Ri 2000 Ir 5 mA Vec
3. 8 50
4. a 15V Veet 15V R 2000 Vr 0 8 V L Level we e Supply Current pe Veca 15V Veet 15V Ri 2000 Vo gt OV Veca 15V Veet 15V Ri 200Q Vo lt OV Vs 0 f 1 MHz Ta 25 C Vs 500 V Ta 25 C 12 14 Threshold Input Current Threshold Input Supply Voltage Ve Capacitance Input Output Resistance Input Output All typical values are at Ta 25 C 1 Duration of IO time lt 50us 3 2002 06 27 TOSHIBA TLP250 INV SWITCHING CHARACTERISTICS Ta 20 70 C Unless otherwise specified CHARACTERISTIC SYMBOL palsies TEST CONDITION UNIT lF 8 mA Switching Time Dispersion tpHL tpLH Voc 15 V between ON and OFF R 200 C 10nF Output Rise Time Output Fall Time o Output Fall Time o Time Common Mode Transient Vom 1000 V lp 8 MA Common Mode Transient Vom 1000 V lp 0 MA Fig 1 lop TEST CIRCUIT Vcc 4 2002 06 27 TOSHIBA TLP250 INV Fig 5 toLH tpHL tr tf TEST CIRCUIT 8 Vom S00 1000V o 10 t te SW A IF 8mA CM CMa saat Vo N 3y Vi 26V SW B IF 0mA CML CM oe CML CMb is the maximum rate of rise fall of the common mode voltage that can be sustained with the output voltage in the low high state 5 2002 06 27 TOSHIBA TLP250 INV RESTRICTIONS ON PRODUCT USE 000707EBC e TOSHIBA is continually working to improve the quality and reliability of its products Neve
5. rtheless semiconductor devices in general can malfunction or fail due to their inherent electrical sensitivity and vulnerability to physical stress It is the responsibility of the buyer when utilizing TOSHIBA products to comply with the standards of safety in making a safe design for the entire system and to avoid situations in which a malfunction or failure of such TOSHIBA products could cause loss of human life bodily injury or damage to property In developing your designs please ensure that TOSHIBA products are used within specified operating ranges as set forth in the most recent TOSHIBA products specifications Also please keep in mind the precautions and conditions set forth in the Handling Guide for Semiconductor Devices or TOSHIBA Semiconductor Reliability Handbook etc The TOSHIBA products listed in this document are intended for usage in general electronics applications computer personal equipment office equipment measuring equipment industrial robotics domestic appliances etc These TOSHIBA products are neither intended nor warranted for usage in equipment that requires extraordinarily high quality and or reliability or a malfunction or failure of which may cause loss of human life or bodily injury Unintended Usage Unintended Usage include atomic energy control instruments airplane or spaceship instruments transportation instruments traffic signal instruments combustion control instruments medical in
6. struments all types of safety devices etc Unintended Usage of TOSHIBA products listed in this document shall be made at the customer s own risk Gallium arsenide GaAs is a substance used in the products described in this document GaAs dust and fumes are toxic Do not break cut or pulverize the product or use chemicals to dissolve them When disposing of the products follow the appropriate regulations Do not dispose of the products with other industrial waste or with domestic garbage The products described in this document are subject to the foreign exchange and foreign trade laws The information contained herein is presented only as a guide for the applications of our products No responsibility is assumed by TOSHIBA CORPORATION for any infringements of intellectual property or other rights of the third parties which may result from its use No license is granted by implication or otherwise under any intellectual property or other rights of TOSHIBA CORPORATION or others The information contained herein is subject to change without notice 6 2002 06 27 WWW ALLDATASHEET COM Copyright Each Manufacturing Company All Datasheets cannot be modified without permission T his datasheet has been download from www AllDataSheet com 100 Free DataSheet Search Site Free Download No Register Fast Search System www AlIDataSheet com file C Documents and Settings seektime HEt S H 111 html2006 01 18 2S 5 2
Download Pdf Manuals
Related Search
TOSHIBA TLP250(INV) Manual