Home

nokia 5730 phone Manual

1. SS 93 and ey pamiove the GPS BT WLAN ANTENNA with the remove the ASSY with the tweezers tweezers 35 Remove the ANTENNA ASSEMBLY with the 36 Release th the DC TACK edge naen tweezers remove the DC JACK with the tweezers 17 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 18 37 Use the dental tool to release the IHF SPEAKER and the IHF SPEAKER gasket Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 Fa T p i G oer LOPS Hno A T Ea gt a neg N LN ni T al push both buttons cot the SIDE KEY with SS 93 to release it Then remove the SIDE KEY with the tweezers END OF DISASSEMBLY 39 Nokia 5730 XpressMusic disassembly is now complete Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 Ca re Service Manual Level 1 amp 2 11 ASSEMBLY HINTS 1 When placing the QWERTY DOMESHEET make sure 2 First push the DYNAMIC FLEX with the SS 93 into that these holes are aligned place against the FLEX PLANE as shown Next connect the connector to the PWB Then slide the FLEX PLANE into the gap and fasten the small clip 3 When assembling the other end of the DYNAMIC 4 Tighten the screw to the torque of 16 Nem FLEX make sure that the connector goes under the two clips shown Connect the connector and then press the FLEX SLIDER into the correct place so that the smal
2. 93 Be careful not to damage EARPIECE HOLDER with the tweezers the connector f fi al E A ei RT 11 Carefully release the LCD with the SRT 6 12 Carefu direction shown ai ARR A B ae a 4 13 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 14 Use the SRT 6t to release t the clips holding the ACCENT BAND QWERTY BRU i ct i on A N ii EN 15 Use the SS 93 to detach the QWERTY KEYMAT 16 Remove the USB DOOR by pulling it to the adhesive on the right side Pull the QWERTY KEYMAT direction shown in the direction shown 17 Turn the phone and use the SRT 6 to remove the 18 Separate the AUDIO ACCENT BAND AUDIO ACCENT BAND from the B Cover Assembly TIP Use the SRT 6 NOKIA text facing up 14 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 19 Unscrew these five TORX size 4 screws in the 20 Close the slide a bit until the two screws order shown Discard them become visible small image Unscrew these three TORX size 4 screws 21 Rotate the SLIDE ASSY and unscrew the TORX size 4 screw the Camera connector Take out the SIDEKEYFLEX with the tweezers 23 Pull out the Camera connector with the 24 Open the locking mechanism of AV connector tweezers and remove the Camera As
3. Nokia 5730 XpressMusic RM 465 a re Service Manual Level 1 amp 2 SERVICE MANUAL Level 1 amp 2 NOKIA 3 30 XpressMusic RM 465 Transceiver characteristics Band g Noca XpressMusic GSM 850 900 1800 1900 WCDMA 900 1900 2100 Display 2 4 QVGA 320x240 16M colours O E mm Keypad Full QWERTY keyboard Camera Main camera 3 2 Mpix Secondary camera VGA Operating System Series 60 release 3 2 Connections 2 mm charger 3 5 mm AV connector Bluetooth 2 0 EDR USB 2 0 Micro USB A GPS WLAN 802 11b g Transceiver with BL 4U battery pack Talk time Standby Talk times are network Up to 270 hours parameters and phone settings 1 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re Service Manual Level 1 amp 2 Table of contents Deg o N A 3 la CODON orion delas 4 3 Wamings and CAUNONS sesasine ai esac aed rere cadet iaa Eada eod aaa a aaraa e a a arbada aieneak 5 3 1 lala 5 3 2 CA a access acces eee eee 5 o A 6 Js Ceana MAN IN MIN rss narraciones lianas l 6 Battery information ccocococociccuonnnnononenacunnnnnnaniconnnnanannnnonanannnnnnonanononanenonnonannonnnenenacnnnonenanenennnnonacncnanonannonnnenanaonanananacnnnenenesns 8 Ta EXPO 9 Bu SAIVICO CONS aE E 10 D ao 11 10 DIS CD AS 12 TE ASSIM iia cedro EE 19 12 Solder ONO ne nT 21 2 Confidential e Copyright O 2009 NOKIA e All rights reserv
4. ONAU SPEAKER 10212 IHF FRONT GASKET B COVER 10214 TYPE LABEL fi 10206 AUDIO ACCENT BAND 10219 SCREW 1 8X3 10221 l SCREW 1 4X4 5 10222 BATTERY COVER n r 9 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Only available as assembly These parts can not be reused after removal NOKIA Care 8 SERVICE DEVICES 10 FLS 5 Flash Device BL 4U NOKIA BL 4U Battery CA 101 Service Cable SS 198 UI flex assembly jig Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 AC 4 Travel Charger NOKIA Standa Toolkit V2 s A a A iy 4 A i ae Mz a k Sy O SA NMP standard toolkit v2 For more information refer to the Service Bulletin SB 011 on NOKIA Online Supplier or manufacturer contacts for tool re order can be found in Recommended service equipment document on NOKIA Online Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 Ca re Service Manual Level 1 amp 2 9 SW UPDATE Flash concept Point of Sales To use the FLS 5 Flash Dongle follow the user guide inside the sales package Please check always for the latest version of flash software wich is available on Nokia Online SERVICE a SOFTWARE EEEE PRODUCT SPECIFIC A BATTERY 11 Confidential e Copyright 2009 NOKIA e All rights reserved Versi
5. all children o Keep the phone dry Precipitation humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits o Do not use or store the phone in dusty dirty areas Its moving parts can be damaged o Do not store the phone in hot areas High temperatures can shorten the life of electronic devices damage batteries and warp or melt certain plastics o Do not store the phone in cold areas When it warms up to its normal temperature moisture can form inside which may damage electronic circuit boards e Do not drop knock or shake the phone Rough handling can break internal circuit boards e Do not use harsh chemicals cleaning solvents or strong detergents to clean the phone Do not paint the phone Paint can clog the moving parts and prevent proper operation a Use only the supplied or an approved replacement antenna Unauthorised antennas modifications or attachments could damage the phone and may violate regulations governing radio devices All of the above suggestions apply equally to the product battery charger or any accessory 7 Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re o Service Manual Level 1 amp 2 6 BATTERY INFORMATION Note A new battery s full performance is achieved only after two or three complete charge and discharge cycles The battery can be charged and discharged hundred
6. d Nokia Nokia Connecting People and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation Other product and company names mentioned herein may be trademarks or tradenames of their respective owners Nokia operates a policy of continuous development Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice Under no circumstances shall Nokia be responsible for any loss of data or income or any special incidental consequential or indirect damages howsoever caused The contents of this document are provided as is Except as required by applicable law no warranties of any kind either express or implied including but not limited to the implied warranties of merchantability and fitness for a particular purpose are made in relation to the accuracy reliability or contents of this document Nokia reserves the right to revise this document or withdraw it at any time without prior notice The availability of particular products may vary by region IMPORTANT This document is intended for use by qualified service personnel only 4 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re o Service Manual Level 1 amp 2 3 WARNINGS AND CAUTIONS Please refer to the phone s user guide for instructions relating to operation care and maintenance including important safety in
7. e the capacity and lifetime of the battery Always try to keep the battery between 15 C and 25 C 59 F and 77 F A phone with a hot or cold battery may temporarily not work even when the battery is fully charged Batteries performance is particularly limited in temperatures well below freezing Do not dispose batteries in a fire Dispose of batteries according to local regulations e g recycling Do not dispose as household waste 8 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 Ca re Service Manual Level 1 amp 2 7 EXPLODED VIEW T9 KEYMAT ASSEMBLY 10003 Mi WINDOW ASSY 10001 A COVER ASSEMBLY 10002 EARPIECE HOLDER METAL 10007 A LOD AM 240x320 10006 EARPIECE 10008 2RS UI FLEX ASSEMBLY a 10009 FLEX SLIDER 10103 28 FLEX PLANE 10201 SLIDE MODULE Q 2RU DYNAMIC FLEX 10102 QWERTY KEYMAT SCREW 1 4X2 5 10010 ae gt SCREW 1 4X3 4 10011 l SCREW RF1 6X4 5 10104 2RT CAMERA FLEX ASSEMBLY 10208 A1 LIGHT SWAP PACKAGE 10204 10206 19998 10204 LIGHT SWAP PWB 10205 N ANTENNA VOLUME SIDE KEY ASSY ASSEMBLY 10217 10216 2RP AV FLEX ASSY USB SD DOOR 10207 10218 Fa GPS BT WLAN ANTENNA j DC JACK 10215 10211 A2 B COVER ASSEMBLY 10211 10214 D
8. ed Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re Service Manual Level 1 amp 2 1 CHANGE HISTORY Status VersionNo Date Comments Approved LO 24 04 2009 AAA The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products This Service Manual is to be used only by authorized NOKIA service suppliers and the content of it is confidential Please note that NOKIA provides also other guidance documents e g Service Bulletins for service suppliers follow these regularly and comply with the given instructions While every endeavor has been made to ensure the accuracy of this document some errors may exist If you find any errors or if you have further suggestions please notify NOKIA using the address below CMO Operation amp Logistics Training and Vendor Development Multimedia Creation amp Support mailto Service Manuals nokia com Please keep in mind also that this documentation is continuously being updated and modified SO watch always out for the newest version 3 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re Service Manual Level 1 amp 2 2 COPYRIGHT Copyright 2009 Nokia All rights reserved Reproduction transfer distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibite
9. ervice Manual Level 1 amp 2 Nokia requires that service points have sufficient ESD protection against static electricity when servicing the phone Any product of which the covers are removed must be handled with ESD protection The SIM card can be replaced without ESD protection if the product is otherwise ready for use To replace the covers ESD protection must be applied All electronic parts of the product are susceptible to ESD Resistors too can be damaged by static electricity discharge All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area EPA Every repair action involving opening the product or handling the product components must be done under ESD protection ESD protected spare part packages MUST NOT be opened closed out of an ESD Protected Area For more information and local requirements about ESD protection and ESD Protected Area contact your local Nokia After Market Services representative Confidential e Copyright O 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 a re Service Manual Level 1 amp 2 5 CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years o Keep the phone and all its parts and accessories out of the reach of sm
10. formation Note also the following 3 1 Warnings 1 CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI SKID BRAKING SYSTEMS UNDER CERTAIN FAULT CONDITIONS EMITTED RF ENERGY CAN AFFECT THEIR OPERATION IF NECESSARY CONSULT THE VEHICLE DEALER MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY 2 THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES EG PETROL STATIONS SERVICE STATIONS BLASTING AREAS ETC 3 OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT INCLUDING CELLULAR TELEPHONES MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE 3 2 Cautions 1 Servicing and alignment must be undertaken by qualified personnel only 2 Ensure all work is carried out at an anti static workstation and that an anti static wrist Strap is worn 3 Use only approved components as specified in the parts list 4 Ensure all components modules screws and insulators are correctly re fitted after servicing and alignment 5 Ensure all cables and wires are repositioned correctly 5 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Care 4 ESD PROTECTION Nokia 5730 XpressMusic RM 465 S
11. l gap is eis the DYNAMIC FLEX Wy Nc A m 2 pl i 5 Tighten the screws to the torque of 16 Ncm in 6 Tighten the five TORX size 4 to the torque of 20 the order shown After tightening the first screw Ncm in the order shown close the slide a bit until the two screw holes become visible small image Tighten the two TORX size 4 screws 19 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 7 Tighten the first three TORX size 4 screws M1 4 X 2 5 to the torque of 20 Ncm in the order shown Then tighten the last TORX size 4 screw M1 8 x 3 to the torque of 20 Ncm 20 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 NOKIA Nokia 5730 XpressMusic RM 465 Ca re Service Manual Level 1 amp 2 12 SOLDER COMPONENTS X6401 F3300 X 590 eee etBR RHE H O88 X2 00 X 591 21 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1
12. on 1 0 ISSUE 1 NOKIA Care 10 DISASSEMBLY INSTRUCTION 6 5 Operator Contacts 2 y Pr A a 3 gt E y A n e Y P r sio Y l f Hat Antone Noreen New George Aprts n E O spew meracesy i Inbox a a o My band gt m amp Wed 11 03 2009 1 51 AA Pi A 3 Remove the BATTERY COVER P y ai Y DD Ca Aia 5 Release the A COVER ASSEMBLY from the SLIDE MODULE using the SRT 6 Carefully open the shown comer 12 Confidential e Copyright 2009 NOKIA e All rights reserved Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 2 4 Slide the phone open Unscrew the first TORX 4 M1 8 x 3 screw Then unscrew the three TORX 4 M1 4 x 2 5 screws in the order shown Discard them AAAS Piva Bey ihe 6 Carefully lift up the top side of the A COVER and at the same time push it to the left so that ITU KEYMAT latches open Check that ITU latches are not broken Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 ale 1 a han ee y P 4 y Pri y Fi i Hs l Rs ea MEE h po Ee 0 e 0 Do AAN 4 a mE NN Na Poy i lad a a pl 7 Remember to protect the LCD with protective 8 Separate the KEYMAT ASSEMBLY from the A COVER film ASSEMBLY 9 Release the EARPIECE HOLDER and remove it with 10 Open the LCD connector from the 2 MX UI FLEX the tweezers Then separate the EARPIECE from the ASSEMBLY with the SS
13. s of times but it will eventually wear out When the operating time talk time and standby time is noticeably shorter than normal it is time to buy a new battery Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer Unplug the charger when not in use Do not leave the battery connected to a charger for longer than a week since overcharging may shorten its lifetime If left unused a fully charged battery will discharge itself over time Temperature extremes can affect the ability of your battery to charge For good operation times with Ni Cd NiMh batteries discharge the battery from time to time by leaving the product switched on until it turns itself off or by using the battery discharge facility of any approved accessory available for the product Do not attempt to discharge the battery by any other means Use the battery only for its intended purpose Never use any charger or battery which is damaged Do not short circuit the battery Accidental short circuiting can occur when a metallic object coin clip or pen causes direct connection of the and terminals of the battery metal strips on the battery for example when you carry a spare battery in your pocket or purse Shortcircuiting the terminals may damage the battery or the connecting object Leaving the battery in hot or cold places such as in a closed car in summer or winter conditions will reduc
14. sembly Be with the SS 93 and pull out the connector with the careful not to damage the connector tweezers 15 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 SA ds i gt Le ed did dd a A PA BA A Salut rth steer PREAS 25 Use the SS 93 to lift the engine module and 26 Pandye the FLEX PLANE from the engine er carefully separate it from the B COVER by opening a small clip with the dental tool 27 Open the DYNAMIC FLEX connector with the SRT 28 Separate the engine board and the SLIDE 6 Be careful not to damage the connector MODULE 29 Remove the FLEX SLIDER using the SS 93 30 Open the connector of the DYNAMIC FLEX and separate it from the SLIDE MODULE Be careful to not to damage the connector 16 Confidential e Copyright 2009 NOKIA e All rights reserved Version 1 0 ISSUE 1 Nokia 5730 XpressMusic RM 465 Service Manual Level 1 amp 2 aT Detach the 2 MX UI FLEX ame from the 32 Start aie the QWERTY DOM ESHEET with the SLIDE MODULE with the SS 93 Discard the 2MX UI dental tool Carefully remove the QWERTY FLEX ASSEMBLY do not use it again Remove the DOMESHEET Make sure that the whole QWERTY adhesive stains from the SLIDE MODULE DOMESHEET is removed ay af Nits iv fps AAN i wate iis 1 alg Pct rit ata YT Lift up the AV FLEX ASSY with the

nokia 5730 phone Manual

Contents

Download Pdf Manuals

Related Search

Related Contents