TOSHIBA PHOTOCOUPLER GaA As IRED PHOTO-IC TLP2066 Manual(1)
Contents
1. Note 4 A ceramic capacitor 0 1 uF should be connected from pin 6 to pin 4 to stabilize the operation of the high gain linear amplifier Failure to provide the bypass may impair the switching property The total lead length between capacitor and coupler should not exceed 1 cm 3 2007 11 20 TOSHIBA Switching Characteristics Unless otherwise specified Ta 40 100 C VCC 3 3V a se Test Y Characteristic Symbol Circuit Conditions Min Typ Max Unit Propagation delay time tpHL to logic high output Propagation delay time ee tpLH to logic low output Propagation delay time dis x tpHL to logic high output Propagation delay time tpLH to logic low output Switching time dispersion tpHL eal ON and OFF EA Output tal ime 90 10 fall time 90 10 Output rise time 10 90 Common mode transient immunity at high Level output Common mode transient immunity at low level output All typical values are at Ta 25 C IF 0 gt 12mMA Rin 100 2 CL 15pF IF 12 0mA Note 5 Vin 0 gt 3 3V Rin 220Q IF 0 gt 8mA Cin 47pF VIN 3 3 0V C_ 15pF IF 8 gt 0mA Note 5 IF 12mMA Rin 1002 CL 15pF Note 5 IpF 0 gt 12mA Rin 100 2 C_ 15pF lF 12 0mA Note 5 Vem 1000Vp p F OmA Vo Min 2V Ta 25 C Vem 1000Vp p IF 12mA Vo Max 0 8V Ta 25 C Note 5 CL is approximately 15pF which includes probe and Jig stray wiring capacitance TEST CIRCUIT 1 VOL TEST CIRCUIT 2 VOH TLP22. 066 TEST CIRCUIT 3 ICCL TEST CIRCUIT 4 ICCH 2007 11 20 TOSHIBA TEST CIRCUIT 5 tpHL toLH I 12mA P G f 5MHz duty 50 tr tf 5ns a INPUT MONITORING NODE CL 15pF CL is capacitance of the probe and JIG P G Pulse Generator TEST CIRCUIT 6 tpHL toLH Vin 3 3V P G f 5MHz duty 50 tr tf 5ns INPUT MONITORING NODE Vo MONITORING CL 15pF NODE Cin 47pF CL is capacitance of the probe and JIG P G Pulse Generator TLP2066 50 IF tf tr Vo lt lt gt zo OH 1 5V 10 VoL 50 VIN tf tr Vo lt gt lt gt V 90 OH 1 5V r 10 VoL TEST CIRCUIT 7 Common Mode Transient Immunity Test Circuit 2007 11 20 TOSHIBA TLP2066 RESTRICTIONS ON PRODUCT USE 20070701 EN e The information contained herein is subject to change without notice e TOSHIBA is continually working to improve the quality and reliability of its products Nevertheless semiconductor devices in general can malfunction or fail due to their inherent electrical sensitivity and vulnerability to physical stress It is the responsibility of the buyer when utilizing TOSHIBA products to comply with the standards of safety in making a safe design for the entire system and to avoid situations in which a malfunction or failure of such TOSHIBA products could cause loss of human life bodily injury or damage to property In developing your designs please ensure that TOSHIBA pr
3. LA FOSHI BA Wma MWR NY Sm TLP2066 TOSHIBA PHOTOCOUPLER GaAfAs IRED amp PHOTO IC TLP2066 FA Factory Automation Unit in mm High Speed Interface 3 3V Supply Voltage The Toshiba TLP2066 consists of a GaAfAs light emitting diode and an integrated high gain high speed photodetector TLP2066 operates with 3 3 V supply voltage Toshiba provides the TLP116 for supply voltage 5V type Inverter logic totempole output Package type MFSOP6 Guaranteed performance over temperature 40 100 C Power supply voltage 3 0 3 6V input thresholds current IFHL 5mMA Max Propagation delay time toHL tpLH 60ns Max pag y tp Max TOENE Switching speed 2OMBd TYP NRZ Weight 0 09 g Typ Common mode transient immunity 15kV us Isolation voltage 3750Vrms UL recognition UL1577 under application Pin Configuration Top View 1 ANODE 3 CATHODE Truth Table 4 GND Output 5 VO H ON ON L 6 VCC OFF L OFF ON OFF H 0 1uF bypass capacitor must be connected between pins 6 and 4 1 2007 11 20 TOSHIBA TLP2066 Absolute Maximum Ratings Ta 25 C Characteristic Symbol Forward current IF 25 mA Forward current derating Ta285 C AIF ATa Peak transient forward current Note1 10 40 fReversewoltage LR Joutputcurent tg Tt Joutputvoltage LC e supplywttage ce 40 40 100 Output power dissipation DETECTOR Operating temp
4. epresentative for product by product details in this document regarding RoHS compatibility Please use these products in this document in compliance with all applicable laws and regulations that regulate the inclusion or use of controlled substances Toshiba assumes no liability for damage or losses occurring as a result of noncompliance with applicable laws and regulations 6 2007 11 20
5. erature range Topr 40 100 Storage temperature range Tstg 55 125 Lead solder temperature 10s Isolation voltage AC 1min R H lt 60 Ta 25 C Note2 Note Using continuously under heavy loads e g the application of high temperature current voltage and the significant change in temperature etc may cause this product to decrease in the reliability significantly even if the operating conditions i e operating temperature current voltage etc are within the absolute maximum ratings Please design the appropriate reliability upon reviewing the Toshiba Semiconductor Reliability Handbook Handling Precautions Derating Concept and Methods and individual reliability data i e reliability test report and estimated failure rate etc Note1 Pulse width PWs1us 300pps Note2 This device is regarded as a two terminal device pins 1 and 3 are shorted together as are pins 4 5 and 6 Recommended Operating Conditions inputcurrent on rm s s ma Le Input voltage OFF VF OFF Supply votage votes voo so This item denotes operating ranges not meaning of recommended operating conditions Note Recommended operating conditions are given as a design guideline to obtain expected performance of the device Additionally each item is an independent guideline respectively In developing designs using this product please confirm specified characteristics shown in this document Note3 The detector of t
6. his product requires a power supply voltage VCC of 3 0 V higher for stable operation If the VCC is lower than this value an ICCH may increase or an output may be unstable Be sure to use the product after checking the supply current and the operation of a power on off Note 4 A ceramic capacitor 0 1 uF should be connected from pin 6 to pin 4 to stabilize the operation of the high gain linear amplifier Failure to provide the bypass may impair the switching property The total lead length between capacitor and coupler should not exceed 1 cm 2 2007 11 20 TOSHIBA TLP2066 Electrical Characteristics Unless otherwise specified Ta 40 100 C VCC 3 0 3 6 V ye Test input forward eres ipa am ernie Temperature coefficient AVF ATa _ IF 10mA 2 mvV C of forward voltage Input reverse current ER VR 6V Ta 25 C a Input capacitance oe V 0 f 1MHz Ta 25 C ere a mala Input current logic low IFHL l0 1 6mA V o lt 0 6V output Input voltage logic high p eae VFLH lt lo 0 02mA V gt 2 0V ae output All typical values are at Ta 25 C VCC 3 3V IF ON 12mA unless otherwise specified Isolation Characteristics Ta 25 C Characteristic Symbol Test Conditions Capacitance input to output Vs 0 f 1MHz Note 2 fos oF o peer eee pe eae Note 2 mol tf AC 1 minute 3750 rms Isolation voltage BVs AC 1 second in oil 10000 DC 1 minute in oil 10000 ve
7. oducts are used within specified operating ranges as set forth in the most recent TOSHIBA products specifications Also please keep in mind the precautions and conditions set forth in the Handling Guide for Semiconductor Devices or TOSHIBA Semiconductor Reliability Handbook etc The TOSHIBA products listed in this document are intended for usage in general electronics applications computer personal equipment office equipment measuring equipment industrial robotics domestic appliances etc These TOSHIBA products are neither intended nor warranted for usage in equipment that requires extraordinarily high quality and or reliability or a malfunction or failure of which may cause loss of human life or bodily injury Unintended Usage Unintended Usage include atomic energy control instruments airplane or spaceship instruments transportation instruments traffic signal instruments combustion control instruments medical instruments all types of safety devices etc Unintended Usage of TOSHIBA products listed in his document shall be made at the customer s own risk The products described in this document shall not be used or embedded to any downstream products of which manufacture use and or sale are prohibited under any applicable laws and regulations GaAs Gallium Arsenide is used in this product The dust or vapor is harmful to the human body Do not break cut crush or dissolve chemically Please contact your sales r
Download Pdf Manuals
Related Search
TOSHIBA PHOTOCOUPLER GaA As IRED PHOTO IC TLP2066 Manual(1)